+- CarTechnoloGY (https://cartechnology.co.uk)
+-- Forum: Discussions All about Software and Hardware (https://cartechnology.co.uk/forumdisplay.php?fid=310)
+--- Forum: Automotive Help & Discussions / Software and Hardware (https://cartechnology.co.uk/forumdisplay.php?fid=40)
+---- Forum: VAG Group (VW - Audi - Seat - Skoda - Bentley) (https://cartechnology.co.uk/forumdisplay.php?fid=55)
+---- Thread: Solved ✔ VW T6 2.0TDI CR 110KW ELECTRICAL ISSUE (/showthread.php?tid=71240)
VW T6 2.0TDI CR 110KW ELECTRICAL ISSUE - ELMEPRO - 08-11-2022
Heloo!
I got a problem..
VW TRANSPORTER T6
2.0 TDI CR 110KW CXHA Delphi DCM6.2
WV1ZZZ7HZGH140585
In summer +20`C no problems
Situation 1 10`C
Start cold engine
Drive 200meters after that
Glow plug flashing no power
Recycle ignition all ok no problem anymore if engine warm
Situation 2 now 4-5`C
engine will start and run badly feels like half cylinders but not that bad!
Glow plug will flash no check engine
After a 2-5min engine running
turn of ignition start car again and no problem no faults
when engine will rest some time, again same problem, sometimes
Is there a TPI for it?
Were should i start look?
Ecu was tuned In Germany and wery badly hard to drive and bad torque curve(not touched yet)
Ecu not opened,ecu connector ok
Fault codes:
25796 - Body Control Module (Central Electric)
U0140 00 [044] - No Communications
15560 - EGR Sensor 1
P046C 00 [108] - Implausible Signal
30802 - Supply Voltage for Fuel Injector Group B
P2149 00 [167] - Open Circuit
16056 - Oil Pressure Switch
P164B 00 [096] - Malfunction
RE: VW T6 2.0TDI CR 110KW ELECTRICAL ISSUE - Kayhan 17# - 08-11-2022
Clean EGR or do EGR Off and the problem should be history
RE: VW T6 2.0TDI CR 110KW ELECTRICAL ISSUE - ELMEPRO - 08-11-2022
(08-11-2022, 12:54 PM)Kayhan 17# Wrote: Clean EGR or do EGR Off and the problem should be history
Its not egr, its wiring or ecu im asking meybe there is tpi for it or somone had this problem, i rilly dont want take apart eriting.
RE: VW T6 2.0TDI CR 110KW ELECTRICAL ISSUE - KeeleyKaayz - 22-01-2023
P2149
Check for broken wires for injectors under the intercooler
p046c
Check for mechanical fault in EGR, pay attention to small bearing Inside EGR actuator
RE: VW T6 2.0TDI CR 110KW ELECTRICAL ISSUE - ELMEPRO - 22-01-2023
(22-01-2023, 14:12 PM)KeeleyKaayz Wrote: P2149you will not believe but i manage to fix it by adjusting belt timing by one tooth
Check for broken wires for injectors under the intercooler
p046c
Check for mechanical fault in EGR, pay attention to small bearing Inside EGR actuator
Abate egr its just dirty its not bordering me
RE: VW T6 2.0TDI CR 110KW ELECTRICAL ISSUE - KeeleyKaayz - 22-01-2023
Nice! good job bro