ATTENTION !! Users which have not any posts were deleted !
  1. New Emulator

  2. Julie Emulator

  3. Immo Bypass

  4. AUTO-CHIPS

  5. HEXPROG

  6. moe diatronik



RNS315 problem
28-12-2018, 21:06 PM, (This post was last modified: 28-12-2018, 21:12 PM by 1 6 D.)
Post: #1
ZVW  RNS315 problem
Hello, does somebody have similar situation?

Address 37: Navigation (J794)       Labelsspeechless 1K0-035-27x-37.clb
   Part No SW: 3C0 035 279 D    HW: 3C0 035 279 D
   Component: RNS315-EU   H32 0263  
   Serial number: VWZAZ2L3383652
   Coding: 000004310400110000008000
   Shop #: WSC 00015 115 00000
   ASAM Dataset: EV_RNS315EUV2UDS A01004
   ROD: EV_RNS315EUV2UDS.rod
   VCID: 244DB1532FDBF86A92-8070

1 Fault Found:
1048642 - Internal Control Module Memory Check Sum Error 
          B2000 42 [009] - General memory failure
          [New feature! Extended UDS fault detail is only supported by current gen. interfaces]
          Confirmed - Tested Since Memory Clear
             Freeze Frame:
                    Fault Status: 00000001
                    Fault Priority: 4
                    Fault Frequency: 1
                    Mileage: 81330 km
                    Date: 2015.07.10
                    Time: 18:37:07


I should try to update Sw to 270 or solder something? Actual mileage is 137000km
Quote this message in a reply
29-12-2018, 09:35 AM,
Post: #2
RE: RNS315 problem
Bad flash inside rns have u run a map Update ?
Quote this message in a reply
29-12-2018, 13:20 PM,
Post: #3
RE: RNS315 problem
Yes I have tried to make map update, but I tried to make the same update in 3 other RNS315 and always there was no problem.

BTW This fault is very old.
Quote this message in a reply
03-01-2019, 17:09 PM,
Post: #4
RE: RNS315 problem
I have same error, after try map update it ask me assign sd. After install in 1 min i receive error: internel device. In vcds error is same as first post
Quote this message in a reply
04-01-2019, 13:43 PM,
Post: #5
RE: RNS315 problem
I have updated SW to 0270 but problem is still, some workshops told about 100-150euro for repair, probably failure of NAND memory.
Quote this message in a reply
04-01-2019, 15:48 PM,
Post: #6
RE: RNS315 problem
Did you try with disconnect battery for 5mins repeat 2-3times and try.
Quote this message in a reply
11-07-2020, 13:28 PM,
Post: #7
RE: RNS315 problem
Hi guys, also I have this error, I have bought rns315 used and this error is already present, I have tried to update map to 2020, assigned sd ok after some minutes write error internal error and now I haven't navigation map, I have update firmware to ver. 0270 but always same problem and error, how can solve or fix it?
Quote this message in a reply
12-07-2020, 04:40 AM, (This post was last modified: 12-07-2020, 10:48 AM by Mr.Tester.)
Post: #8
RE: RNS315 problem
Hi,

"Internal Device Error" isn't software error and can't be fixed by any sw firmware update.
"Internal Device Error" is hardware fault in 95% of cases and means connection failure between flash chip and motherboard or fault in the flash chip itself. Repairable only by resoldering or replacing of flash chip. No easy and cheap solution.
The fault always exists / is present before the map update, only occurs during the update (when checking mechanism reach address in memory where data can't be write or verify, because part of memory is unaccessible). It's stupid checking mechanism. When fault is rised near the end of storage memory (near the end of update process) in flash chip, sometime is possible to save older (smaller size) navigation database witch will fit to good and accessible part of memory. I have 2 cases in experience. But in the most cases error message not disappear.

Best Regards
M.T.
Quote this message in a reply
[-] The following 3 users say Thank You to Mr.Tester for this post:
  • 1 6 D, audiopoint, bmw320d
30-09-2020, 09:57 AM,
Post: #9
RE: RNS315 problem
(12-07-2020, 04:40 AM)Mr.Tester Wrote:  Hi,

"Internal Device Error" isn't software error and can't be fixed by any sw firmware update.
"Internal Device Error" is hardware fault in 95% of cases and means connection failure between flash chip and motherboard or fault in the flash chip itself. Repairable only by resoldering or replacing of flash chip. No easy and cheap solution.
The fault always exists / is present before the map update, only occurs during the update (when checking mechanism reach address in memory where data can't be write or verify, because part of memory is unaccessible). It's stupid checking mechanism. When fault is rised near the end of storage memory (near the end of update process) in flash chip, sometime is possible to save older (smaller size) navigation database witch will fit to good and accessible part of memory. I have 2 cases in experience. But in the most cases error message not disappear.

Best Regards
M.T.

Do you know which chip needs to be replaced?
are those the two tall ones? (16gb NAND flash memory)
or the small one (128 mbit flash memory)
see attached picture

Kind regards,


Attached Files Thumbnail(s)
   
Quote this message in a reply
30-09-2020, 11:05 AM,
Post: #10
RE: RNS315 problem
I did reflow of big one 16gb NAND.

Kind Regards
M.T.
Quote this message in a reply


Possibly Related Threads…
Thread Author Replies Views Last Post
XZBMW bmw language problem murat332 0 39 4 hours ago
Last Post: murat332
ZVW RNS 510 / Columbus software update problem - SetConfig didn't connect Szogun 3 551 25-05-2021, 10:06 AM
Last Post: Szogun
XZBMW BMW EVO Map update problem Stets 3 360 24-05-2021, 23:03 PM
Last Post: Matofil
ZVW DELPHI MIB2 STD PROBLEM nabilrifi 6 1,331 24-05-2021, 17:53 PM
Last Post: congo11
UNissan Nissan LCN2 sound problem Steve25 0 437 22-04-2021, 16:00 PM
Last Post: Steve25
YTMercedes Mercedes Anti theft Code COMAND PROBLEM javitor52x 1 341 11-03-2021, 10:52 AM
Last Post: javitor52x
  RCD510 Frist 2 Dig Problem DaBotta 1 742 27-02-2021, 17:22 PM
Last Post: kohman2
ZTAudi AUDI MIB2 USA to EU problem with maps huzionet 3 1,254 25-01-2021, 15:40 PM
Last Post: huzionet
  Firmware for rns315 koossie 1 563 21-01-2021, 09:43 AM
Last Post: chaos2go
  Solved ✔ vag mfd problem code bboctavian 4 1,177 16-01-2021, 15:22 PM
Last Post: bboctavian

Forum Jump:


Users browsing this thread:
1 Guest(s)

Return to TopReturn to Content